2001 Sonata Heat/AC Control Problem

Thread view:

Enable EMail Alerts

Start New Thread

Thread rating:

Jared - 11 Apr 2007 16:05 GMT

When the temperature control knob is turned, it goes all the way to the cold
side with no problem. However, if you turn it to the hot, it only goes so
far, then if you "force" it...it clicks 3 times until it reaches the
"hottest" setting.

Any ideas? problem right behind the panel?

Thanks in advance,
Jared

P.S. I have had that whole panel off earlier when there was loose wire on
the radio harness...so I may have been the cause.

Reply to this Message

hyundaitech - 11 Apr 2007 17:35 GMT

Check the cable on the heater box to be sure it's clipped in place
properly. If you didn't take the cable loose from the heater box before
removing, you may have bent the cable or pulled it loose.

It's pretty simple. Stuff your head under the left side of the dash and
rotate the heater control knob back and forth. The cable that's moving is
the temperature control cable. Check to make sure it's not damaged or
bent, check the lever to which it attaches and check to make sure it's
clipped onto the heater case.

Reply to this Message