Funny sparks in a 740

Thread view:

Enable EMail Alerts

Start New Thread

Thread rating:

Mauricio Tavares - 11 Dec 2006 18:42 GMT

Someone I know has a volvo 740 turbo (LH 2.4) with an
interesting problem: two of his spark plugs give out weak sparks and two
give nice and bright ones. He did check that by connecting one spark
plug to each wire and seeing the spark. He has swapped distributor cap,
rotor, and wires, and tested the spark at the coil (nice and uniform).
What else should he check?

Signature

Mauricio raub-kudria-com
(if you need to email me, use this address =)

Reply to this Message

Boris Mohar - 11 Dec 2006 19:07 GMT

> Someone I know has a volvo 740 turbo (LH 2.4) with an
>interesting problem: two of his spark plugs give out weak sparks and two
>give nice and bright ones. He did check that by connecting one spark
>plug to each wire and seeing the spark. He has swapped distributor cap,
>rotor, and wires, and tested the spark at the coil (nice and uniform).
>What else should he check?

Sparkplugs. Thy have internal resistor the frequently goes from few Kilo
ohms to much higher value. Very high value of internal resistance will limit
the current. If you have a bucket full of old sparkplugs check them with
ohmmeter between the tip and the cable end. Some will read open circuit and
still fire (sort of)

Regards,

Boris Mohar

Got Knock? - see:
Viatrack Printed Circuit Designs (among other things) http://www.viatrack.ca

void _-void-_ in the obvious place

Signature

Posted via a free Usenet account from http://www.teranews.com

Reply to this Message

Mauricio Tavares - 12 Dec 2006 03:30 GMT

>> Someone I know has a volvo 740 turbo (LH 2.4) with an
>> interesting problem: two of his spark plugs give out weak sparks and two
[quoted text clipped - 8 lines]
> ohmmeter between the tip and the cable end. Some will read open circuit and
> still fire (sort of)

But why if he connected the same spark plug to the 4 different spark
plug wires he would get two wires producing bright sparks and two
producing wimpy ones?

> Regards,
>
[quoted text clipped - 6 lines]
>
>

Signature

Mauricio raub-kudria-com
(if you need to email me, use this address =)

Reply to this Message

Tony - 12 Dec 2006 16:15 GMT

>>> Someone I know has a volvo 740 turbo (LH 2.4) with an
>>> interesting problem: two of his spark plugs give out weak sparks and
>>> two give nice and bright ones. He did check that by connecting one
>>> spark plug to each wire and seeing the spark. He has swapped
>>> distributor cap, rotor, and wires, and tested the spark at the coil
>>> (nice and uniform). What else should he check?

Is the distributor rotor arm bent or loose? Check inside the cap for
damage after the bent arm has been going round. The 2 good sparks
contact points maybe bent away from the centre increasing the distance
from the bad ones.

Never heard of it before, but its the only thing I can think of if
everything else is ok.

>> Sparkplugs. Thy have internal resistor the frequently goes from few Kilo
>> ohms to much higher value. Very high value of internal resistance
[quoted text clipped - 7 lines]
> plug wires he would get two wires producing bright sparks and two
> producing wimpy ones?

Could be something to do with Engine management, crank sensor maybe, are
you sure a good engine does not do this?

Is there a more direct symptom? Is the engine actually running badly?

--
Tony

Reply to this Message

Tony - 12 Dec 2006 16:51 GMT

>>>> Someone I know has a volvo 740 turbo (LH 2.4) with an
>>>> interesting problem: two of his spark plugs give out weak sparks and
[quoted text clipped - 10 lines]
> Never heard of it before, but its the only thing I can think of if
> everything else is ok.

Also is the cap seated properly? ie nothing trapped between the cap and
the distributor base.

Does the cap wobble when pushed on?

--
Tony

Reply to this Message

James Sweet - 13 Dec 2006 03:19 GMT

>>>>> Someone I know has a volvo 740 turbo (LH 2.4) with an
>>>>> interesting problem: two of his spark plugs give out weak sparks
[quoted text clipped - 15 lines]
>
> Does the cap wobble when pushed on?

It also occurred to me it might be a damaged interrupter plate or
rotting engine wiring harness depending on the year.

Reply to this Message

Boris Mohar - 13 Dec 2006 13:11 GMT

>>> Someone I know has a volvo 740 turbo (LH 2.4) with an
>>> interesting problem: two of his spark plugs give out weak sparks and two
>>> give nice and bright ones. He did check that by connecting one spark
>>> plug to each wire and seeing the spark. He has swapped distributor cap,

Good point. It is not clear the he actually moved same plug from wire to
wire.

Signature

Boris Mohar

--
Posted via a free Usenet account from http://www.teranews.com

Reply to this Message